Effects of Added Plasmin on the Formation and Rheological Properties of Rennet-Induced Skim Milk Gels

¹ Department of Food Science, University of Wisconsin, Madison 53706

Elevated plasmin enzyme activity has been suggested as a likely cause of impaired functional properties that occur in milk from cows either in their latelactational period or that are experiencing mastitis. However, there are conflicting reports on the impact of plasmin on rennet coagulation properties of milk. The effects of added plasmin on the rheological properties, at small and large deformation, of rennet-induced gels were investigated. The microstructure of rennet-induced gels was studied, using confocal scanning laser microscopy. Porcine plasmin was added to reconstituted milk, and samples were incubated at 37°C for between 0.5 to 8 h. The hydrolysis reaction was terminated using soybean trypsin inhibitor. The extent of degradation of caseins was determined with SDS-PAGE. The extent of breakdown of _s- and ß-caseins increased with incubation time with plasmin. Storage modulus of rennet gels decreased linearly with increasing degradation of caseins. There was an increase in the loss tangent parameter of the gels with increasing casein degradation, indicating a more liquid-like gel character. Gelation time decreased until approximately 3 h of incubation with plasmin (when the amounts of intact _s- and ß-caseins were 46 and 50%, respectively); thereafter, gelation time increased considerably. Yield stress of rennet-induced gels decreased with increasing casein breakdown. When the level of casein hydrolysis was high (<40% of intact caseins), the microstructure of rennet-induced gels was drastically altered. Even when there were low levels of casein hydrolysis, the rheological properties of rennet gels were altered, which could have negative impacts on cheese yield and texture.

Key Words: plasmin • rennet coagulation • rheology • proteolysis

Submitted on October 20, 2001
Accepted on December 21, 2001

This article has been cited by other articles:

				P. C. B. Vianna, G. Mazal, M. V. Santos, H. M. A. Bolini, and M. L. Gigante Microbial and Sensory Changes Throughout the Ripening of Prato Cheese Made from Milk with Different Levels of Somatic Cells J Dairy Sci, May 1, 2008; 91(5): 1743 - 1750. [Abstract] [Full Text] [PDF]

				G. Theodorou, A. Kominakis, E. Rogdakis, and I. Politis Factors Affecting the Plasmin-Plasminogen System in Milk Obtained from Three Greek Dairy Sheep Breeds with Major Differences in Milk Production Capacity J Dairy Sci, July 1, 2007; 90(7): 3263 - 3269. [Abstract] [Full Text] [PDF]

				J. Choi, D. S. Horne, and J. A. Lucey Effect of Insoluble Calcium Concentration on Rennet Coagulation Properties of Milk J Dairy Sci, June 1, 2007; 90(6): 2612 - 2623. [Abstract] [Full Text] [PDF]

				B. Ismail, L. H. Choi, L. M. Were, and S. S. Nielsen Activity and nature of plasminogen activators associated with the casein micelle. J Dairy Sci, September 1, 2006; 89(9): 3285 - 3295. [Abstract] [Full Text] [PDF]

				K. A. Frohbieter, B. Ismail, S. S. Nielsen, and K. D. Hayes Effects of Pseudomonas fluorescens M3/6 Bacterial Protease on Plasmin System and Plasminogen Activation J Dairy Sci, October 1, 2005; 88(10): 3392 - 3401. [Abstract] [Full Text] [PDF]

				L. Bianchi, A. Bolla, E. Budelli, A. Caroli, C. Casoli, M. Pauselli, and E. Duranti Effect of Udder Health Status and Lactation Phase on the Characteristics of Sardinian Ewe Milk J Dairy Sci, August 1, 2004; 87(8): 2401 - 2408. [Abstract] [Full Text] [PDF]

				G. Leitner, U. Merin, and N. Silanikove Changes in Milk Composition as Affected by Subclinical Mastitis in Goats J Dairy Sci, June 1, 2004; 87(6): 1719 - 1726. [Abstract] [Full Text] [PDF]

				J. A. Lucey, M. E. Johnson, and D. S. Horne Invited Review: Perspectives on the Basis of the Rheology and Texture Properties of Cheese J Dairy Sci, September 1, 2003; 86(9): 2725 - 2743. [Abstract] [Full Text] [PDF]

				C. L. C. Esteves, J. A. Lucey, T. Wang, and E. M. V. Pires Effect of pH on the Gelation Properties of Skim Milk Gels Made From Plant Coagulants and Chymosin J Dairy Sci, August 1, 2003; 86(8): 2558 - 2567. [Abstract] [Full Text] [PDF]